- Savell, Jeffrey; Lucia, Lisa; Laster, Brittany; Harris, Kerri; Castillo, Alejandro
- Texas A&M University
- Start date
- End date
During recent years, the beef industry has suffered from an increased number of positive E. coli O157:H7 results, recalls, and related illnesses. Therefore, the beef industry continues to search for ways to improve the safety of beef and reduce the risk of E. coli O157:H7 contamination.
One area that has received a great deal of attention relates to E. coli O157:H7 contamination of products intended for the production of non-intact beef products. USDA-FSIS has questioned the ability of further processors to support the fact that E. coli O157:H7 is not a reasonably likely to occur food safety hazard on the trimmed subprimals that are often used to produce these non-intact products. Previous research (Kennedy, Williams, Brown, & Minerich, 2006) found that the prevalence of E. coli O157:H7 on subprimals was extremely low. However, FSIS has questioned the use of these data to support that E. coli O157:H7 is not reasonably likely to occur because these data were collected in 2004, which was a year with a low prevalence for E. coli O157:H7 in ground beef.
It has been theorized that trimming during the fabrication process would reduce E. coli O157:H7; however, this has not been supported by peer-reviewed research. We propose to conduct a study to determine the effectiveness of trimming original carcass surfaces during fabrication of subprimals on the reduction of E. coli O157:H7.
Objective: To use surrogate microorganisms as a model to evaluate the impact of trimming exterior carcass surfaces during the fabrication of subprimals in order to reduce E. coli O157:H7 contamination.
- More information
Findings: This research showed that for eight different subprimals generated from carcasses that had been inoculated with rifampicin-resistant surrogates counts were numerically highest on the exterior carcass fat surface samples. It also showed that trimmed lean samples typically had the lowest numerical counts of all samples taken from each subprimal. Overall, the results from this study showed that trimming exterior carcass surface fat from subprimals has the potential to decrease contamination levels on the fat surfaces.
- Funding Source
- Nat'l. Cattlemen's Beef Assoc.
- Project number
- Risk Assessment, Management, and Communication
- Natural Toxins
- Viruses and Prions
- Bacterial Pathogens
- Chemical Contaminants
- Legislation and Regulations
- Escherichia coli